一．    設備簡介

One Equipment introduction

日化品廠產生的廢水量一般都不會很大，但是這些廢水中的污染濃度非常高，就算日化品的生產量再大，它的廢水因?yàn)槿栈飞a(chǎn)工序的原因?qū)е聫U水的產生量也不會太大，不過其水量和水質的起伏也比較大不規律，不止如此廢水中的LAS和COD的濃度也比一般的水質高出很多，其水中的活性劑在水中的存貨量非常的少因此另一方面也會造成破壞水質的張力。如果遇到生物處理時活性劑又不得超過1000mg/L，因?yàn)樯锾幚砉に囋谟龅接卸疚镔|(zhì)在好氧的階段會產生大量的泡沫；而中水回用他是一體化全自動的生物膜反應器，也叫MBR設備它的生物處理技術可完全代替了傳統的中水處理工藝，其可從進水到達標出水一體達成，可大|大的減少用地面積和人工，而且出水穩定易操作可的去除水中的各種有毒物質和，產出污泥量非常少，而水中的懸浮物質幾乎接近零排出，還含有消毒殺菌的作用，直接處理到中水達標的標準。

The amount of waste water produced by daily chemical products factories is generally not very large, but the pollution concentration of these waste water is very high. No matter how large the production volume of daily chemical products is, the amount of waste water produced due to the production process of daily chemical products will not be too large, but the fluctuation of water quantity and quality is relatively large and irregular, More than that, the concentration of LAS and COD in wastewater is much higher than the general water quality, and the inventory of active agent in water is very small, so on the other hand, it will cause the tension of damaging water quality. In case of biological treatment, the active agent should not exceed 1000mg/L, because the biological treatment process will produce a large amount of foam when it meets toxic substances in the aerobic stage. The reclaimed water reuse is an integrated automatic biofilm reactor, also known as MBR equipment. Its biological treatment technology can completely replace the traditional reclaimed water treatment process. It can be achieved from the inlet water to the standard outlet water. It can greatly reduce the land area and manpower, and the effluent is stable and easy to operate. It can remove all kinds of toxic substances and pollutants in the water, and produce very little sludge, The suspended matter in the water is almost zero discharge, and it also has the function of disinfection and sterilization, which can be directly treated to the standard of reclaimed water.

宏潔水務的中水回用設備工藝已采用膜處理技術，包括預處理、超濾系統和反滲透(RO)系統及EDI系統（可選）幾部分。由于廢水通過現代技術的深度處理能夠達到生產用水標準或者生活雜用水標準，使廢水能夠循環使用，這樣企業對于廢水這一塊的整體運行費用得到大|大的降低，對環境保護起到很大的作用。

Membrane treatment technology has been adopted in the process of reclaimed water reuse equipment of Hongjie water, including pretreatment, ultrafiltration system, reverse osmosis (RO) system and EDI system (optional). Due to the advanced treatment of wastewater by modern technology, it can meet the production water standard or domestic miscellaneous water standard, so that the wastewater can be recycled, so that the overall operation cost of the enterprise for wastewater has been greatly reduced, which plays a great role in environmental protection.

二． 設計標準及依據

2、 Design standard and basis

1. 根據用戶提供的詳細水質報告“量身定制”。

1. According to the detailed water quality report provided by the user, "customized".

2. 水處理設備技術條件《JB/T 2932-1999》

2. Technical conditions of water treatment equipment JB / T 2932-1999

3. 用于一般景觀生態用水符合(CJ/T95-2000),

3. The general landscape ecological water use conforms to (CJ / t95-2000),

4. 用于生活雜用水應符合建設部(CJ/48-1999),

4. Domestic miscellaneous water should meet the requirements of the Ministry of construction (CJ / 48-1999),

5. 用于工業循環冷卻水應符合(GB/T50102-2003).

5. The industrial circulating cooling water shall comply with (GB / t50102-2003)

6. 反滲透水處理設備標準《CJ/T119-2000》

6. Standard for reverse osmosis water treatment equipment CJ / t119-2000

7. 低壓開關設備和控制設備成套裝置《IEC439-1 》

7. Complete set of low voltage switchgear and control equipment iec439-1

三．    工藝流程

Three technological process

四． 設計特點

4、 Design features

1. 系統采用全自動控制(同時亦可采用手動控制），系統運行時可設定自動反洗、再生程序；

1. The system adopts full automatic control (manual control is also available), and automatic backwashing and regeneration procedures can be set during system operation;

2. 管道一般采用UPVC材質；

2. UPVC material is generally used for pipes;

3. 集成控制系統和集成儀表系統等，方便操作管理；

3. Integrated control system and instrument system to facilitate operation and management;

4. 設備具有耗材更換自動提示功能，并且耗材的更換周期取決于水質和壓力的變化，而非根據耗材的使用時間，考慮到了各地水質的差異，設計更；

4. The equipment has the function of automatic prompt for the replacement of consumables, and the replacement cycle of consumables depends on the change of water quality and pressure, not on the use time of consumables. Considering the difference of water quality in different places, the design is more reasonable;

5. 能有效地進行固液分離，將廢水中的懸浮物質、膠體物質、生物單元流失的微生物菌群與已凈化的水分開。分離工藝簡單，占地面積小，出水水質好，一般不須經三級處理即可回用。

5. It can effectively carry out solid-liquid separation, and separate the suspended matter, colloidal matter, microbial flora lost by biological units from the purified water. The separation process is simple, covers a small area, and the effluent quality is good. Generally, it can be reused without tertiary treatment.

6. 可使生物處理單元內生物量維持在高濃度，使容積負荷大|大提高，使處理單元水力停留時間大|大的縮短，生物反應器的占地面積相應減少。

6. It can keep the biomass in the biological treatment unit at a high concentration, greatly increase the volume load, greatly shorten the hydraulic retention time of the treatment unit, and correspondingly reduce the floor area of the bioreactor.

7. 由于可防止各種微生物菌群的流失，有利于生長速度緩慢的(硝化等)的生長，從而使系統中各種代謝過程順利進行。

7. Because it can prevent the loss of various microbial flora, it is conducive to the slow growth (nitrification, etc.), so that various metabolic processes in the system can be carried out smoothly.

8. 使一些大分子難降解物的停留時間變長，有利于它們的分解。

8. The longer the residence time of some macromolecular refractory products is beneficial to their decomposition.

9. 膜處理技術與其它的過濾分離技術一樣，在長期的運轉過程中，膜作為一種過濾介質堵塞，膜的通過水量運轉時間而逐漸下降有效的反沖洗和化學清洗可減緩膜通量的下降，維持MBR系統的有效使用壽命。

9. Membrane treatment technology is the same as other filtration and separation technology. In the long-term operation process, the membrane is blocked as a kind of filter medium, and the water flow of membrane decreases gradually with the operation time. Effective backwashing and chemical cleaning can slow down the decline of membrane flux and maintain the effective service life of MBR system.